Gas tank in the cabin - safety

[Getter-Done]

Originally Posted by Accelo

I weighed my axles and 2300 on the front and 1700 on the rear for a total of 4000 lbs. with fuel and me in it.

What time were you on the scales,

Before or after Lunch?.

That would make a Big difference with me.

[franken]

If we think about the 73-91 record of the squares we may want to think they were pretty safe. Similarly, gas tanks were in the cab for about 50 years until 72. Hmm.

[Stocker]

Originally Posted by franken

Similarly, gas tanks were in the cab for about 50 years until 72. Hmm.

Yes, and IIRC, old VW Beetles had the gas tank almost in your lap, part of the crush zone in a head-on collision. Millions of Beetles were sold worldwide. I don't recall hearing about widespread fire danger with them.

[Steeveedee]

I've seen VWs that burned when the fuel hose on the fuel pump cracked due to heat from the exhaust manifold and leaked. It would flow from the gas tank and keep the fire going. I always checked that hose when I did any kind of service on a VW. Still, not that common a problem.

[Accelo]

Originally Posted by Steeveedee

I've seen VWs that burned when the fuel hose on the fuel pump cracked due to heat from the exhaust manifold and leaked. It would flow from the gas tank and keep the fire going. I always checked that hose when I did any kind of service on a VW. Still, not that common a problem.

I was in a Square Back when it burnt to the ground. The truck driver behind me said flames shot out 3' from both windows. It was the second fire while I was inside. The second was from an un-fused circuit to the gasoline heater installed in the front trunk. Shorted and the whole wire was red-hot. I pulled a fence board from the guy's fence we parked next to and used it to pull the wire off. Otherwise, it could have been a total loss like the first one.
Never owned another VW after that and never will.